United Kingdom

Used face masks can be sterilised in a MICROWAVE in just 90 seconds

Some face masks can be sterilised by putting them in a high-power microwave at 1800W for 90 seconds, a study shows. 

N95 respirators, worn by healthcare worker and hailed as the gold-standard for protection from airborne coronavirus particles, can be cleaned using the technique. 

The material remains intact while viruses and bacteria are reduced to acceptable levels. A single N95 mask can undergo microwave sterilisation three times.

However, the blue surgical face masks regularly worn by members of the public lose all ability to filter out aerosols and are useless following the microwaving method.

Researchers say the rapid ability to take contaminated PPE and make them wearable again could be useful if there are shortages of new masks. 

Scroll down for video  

Pictured, the four respirators used in the study. Top, a Kimberley-Clarke N95 respirator which survived intact. Right: metal-free FFP2 respirator which passed the cleaning method. Left: a Honeywell FFP3 respirator which was rendered useless following the sterilisation technique, so too was a generic unbranded PPE mask (bottom)

Blue surgical face masks regularly worn by members of the public (pictured) lose all ability to filter out aerosols and are useless if put in a microwave and subjected to the sterilisation method (stock)

Previous studies have shown the coronavirus can be killed easily by steam, but the impact this has on the mask's structural integrity remains unknown. 

Therefore the researchers put the mask inside a baby bottle steriliser which was filled with 100 or 200ml of water.

When the high-powered waves of energy from the microwave hit the water, it turns to steam, sterilising the mask.

The researchers know this kills SARS-CoV-2, the virus which causes Covid-19, but wanted to see if the mask itself could cope with the strain and if the method could kill bacteria which are also often found in hospital settings. 

To test the latter, the researchers smeared the common bacteria Staphylococcus aureus over the masks to see if the microwave method killed it.  

Four types of respirators were as well as the generic surgical masks seen in healthcare scenarios and increasingly donned by members of the public due to the coronavirus pandemic. 

The Kimberley-Clarke N95 respirator was found to be fit to use after the impromptu treatment, as too was a metal-free FFP2 respirator.

Pictured, a N95 respirator (left0 put inside the baby bottle steriliser (right). Water is added and this, when turned to steam, sterilises the mask 

Wear a mask in the office, at school, and even OUTDOORS if you can't keep a metre apart, WHO urges 

People in areas where there is high transmission of Covid-19 should wear face masks indoors, including in offices and schools, according to new guidance from the World Health Organization (WHO). 

Coverings should also be worn in private homes if someone comes inside who does not live there. 

Other additions to the guidance include children over the age of 12 following the same advice as adults and wearing a mask outside if social distancing of one metre is not possible.   

In the updated guidance sheet, the WHO admits there is 'limited evidence' the masks stop the transmission of coronavirus.

Recent studies have found conflicting evidence about masks, with a landmark piece of research finding they do not stop the wearer catching the virus.   

However, a Honeywell FFP3 respirator and a generic unbranded PPE mask were both damaged by the microwave procedure to the point of being unfit for use.  

In the study, the researchers report that microwaving the less robust surgical masks led to a complete loss of their aerosol filtering capacity because their pores widen when they get wet.

Michael Pascoe, co-author of the study, said: 'Surgical masks are known to lose effectiveness once they become moist – we suspected that microwave disinfection would lead to a similar loss in their ability to filter aerosols and this was confirmed by our lab observations.'

The scientists say that members of the public should not consider microwaving their own masks. 

Professor Adrian Porch, co-author of the study from Cardiff University, said: 'Domestic microwave ovens typically have much lower power, around 800 W, and use rotating turntables rather than a rotating antenna. 

'Significantly longer exposure times would be needed to achieve similar results and it is unknown how this would affect the functioning of the mask. 

'Masks which contain thin wires can even catch fire when placed in a microwave.'      

The team also investigated using dry heat ovens as an alternative approach, which eliminates the need to use steam. 

This method was effective but took much longer, with 90 minutes at 70°C needed to bring the level of bacteria down to acceptable levels. 

But this method did work for all respirators and surgical masks. 

'Mask and respirator models vary considerably and so it is important to ensure the method of decontamination does not compromise their function. 

'Considering the advantages and disadvantages of each approach, we have proposed a reprocessing workflow that practitioners could follow in healthcare settings. 

'Reusing existing PPE could buy vital time during emergencies and save lives,' continued Michael Pascoe. 

How to wear a mask, according to the WHO  

Football news:

Bayern will play Egypt's Al-Ahly or Qatar's Al-Duhail in the Club World Cup semi-finals
Villalibre about delaying time by Athletic: Barcelona is worth a billion euros, and we wanted to win the Super Cup at the cost of our lives
Andrea Pirlo: Juventus want to win a tenth league title. Now is a difficult moment, but the ambitions remain the same
Dynamo crossed the medical examination and Cyberpunk 2077: they decorated the hospital with graphics and stuffed everything with Easter eggs
Joan Laporta: If Messi wants to gain experience in football in America, it will be useful for everyone
Ter Stegen and the Barcelona defenders have filed complaints against Griezmann for commenting on a poor defensive performance after the Super Cup (Cadena SER)
PSG can buy Barca defender Emerson for 25 million euros